TZDC、TZD系列振動電機

使用說明書

TZDC/TZD series Vibration Motor  

河南太行重型機械股份有限公司制造    

            MANUFACTURED BY HENAN TAIHANG HEAVY MACHINERY CO.,LTD

　　型號說明

　　TZDC系列振動電機是我公司與北京科技大學合作研制的新型振動電機，是原TZD系列振動電機的進一步改進，提高了軸承壽命，增大了激振力，減小了偏心塊的質量和飛輪力矩，各項性能優于國內其他型號的振動電機。我公司推薦用戶首選TZDC系列振動電機。如原采用TZD系列振動電機的設備需要更換備件，我公司也及時供應TZD系列振動電機.

　　Model description

　　TZDC series vibration motor is a new type vibration motor,which is developed by our company in cooperation with Beijing Science and Technology University.It is to further improve the original TZD series vibrating motor,so it improves the bearing life,increases the exciting force,reduces the quality and the flywheel moment of the eccentric block.Besides,the all performance is better than other domestic models.Our company recommends users to prefer TZDC series vibrating motor.If the equipment of original TZD series vibrating motor needs replacement,we can supply in time.

　　用途

　　TZDC系列振動電機是在雙軸伸的轉子軸兩端各安裝一組可調偏心塊，利用偏心塊旋轉產生的離心力得到激振力。振動電機的激振力大、能耗小、噪聲低、壽命長。它不僅可用于各種料倉、料斗、溜槽的倉壁振動，還是自同步直線振動篩、振動給料機、振動輸送機等各種振動機械的激振源，是冶金、礦山、煤炭、建材、化工等行業的理想設備，有廣泛的應用范圍。

　　Usage

　　TZDC series vibrating motor is respectively provided with a set of adjustable eccentric block on the both sides of protrudent ends changing shaft.Eccentric block is rotating and the centrifugal force generates the exciting force.The vibrating motor of big exciting force,small energy consumption,low noise and long life.It not only can be used for silo wall vibration hopper of a various material warehouse,hopper,chute,but also is the vibration source of self synchronous linear vibrating screen,vibrating feeder,vibrating conveyor as well as various mechanical vibration.It is an ideal equipment for metallurgy,mining,coal,building materials,chemical industry and a wide range of applications.

　　工作原理及結構特點

　　本系列振動電機為三相380V50HZ異步電動機，封閉自冷式、臥式安裝。

　　TZDC系列振動電機在連續工作時，周圍空氣中不得含有腐蝕性及爆炸性氣體，環境溫度不得超過40度。

　　將振動電機安裝在振動機械上時，振動電機的底腳螺栓必須緊固，每個螺母下必須加彈性墊圈，振動電機運轉初期，由于螺栓、螺母、底座平面間的磨合，會降低緊固力，出現小的松動，故運轉初期應將電機的底腳螺栓多次擰緊，開始時每天緊固一次，兩周后每周檢查緊固一次。

　　振動電機的電纜引線也參與振動，電纜吊掛的曲率半徑應符合表1的規定。電纜從振動電機的引出點至電纜固定支架間的距離應保持500-1000mm。

　　Working principle and structure characteristic

　　This series of vibrating motor is 380V50HZ three phase nonsynchronous motor and the installation of closed self-cold type as well as horizontal type.

　　In continuous operation,the surrounding air shall not contain corrosive and explosive gases,environmental temperature is not exceeding 40 degrees.

　　The vibration motor is installed on the vibrating machinery,the foot bolt of vibration motor must be secured,each nut must add the elastic washer.At the beginning of operation,it will reduce the fastening force and even appear small loose for the rubbing of bolt,nut and a base plane,so the early operation should be the foot bolt motor repeatedly tightened.At first,fastening once a day,two weeks later,check fastening once a week.

　　Cable of vibration motor also participates in the vibration,the radius of curvature of cable hanging should be in accordance with the provisions of table 1.The distance should keep the 500-1000mm between the outlet of vibration motor and the fixing support of cable.

　　表1

　　Table one

　　振動電機運輸過程中或長期閑置時，可能會受潮，使用前應檢查繞組的絕緣，如受潮，應采用相應方法處理。

　　TZDC系列振動電機的軸承應定期補充油脂（3#復合鋰基脂），一般一周補油一次。待振動電機處于非狀態用油槍在油嘴處注入。環境溫度低于-5度時采用2#復合鋰基脂。

　　振動電機一般運行4-6個月小修一次，一年大修一次。小修時清除機體積塵，檢查線圈的絕緣電阻、接線是否牢固，及時清除隱患。大修時應拆開電機，用壓縮空氣將內外吹凈，檢查軸承的磨損，更換新的潤滑脂。

　　The transport process in the vibration motor or long-term idle,may be affected with damp,insulation,check the winding such as moisture before use,should be treated by corresponding method.

　　TZDC series vibrating motor bearing should be regularly added fats(3#lithium complex grease),generally a week fill oil a.For vibration motor is in non state injected with oil gun in choke.The ambient temperature below-5 degrees with 2#complex lithium grease.

　　The vibration motor is generally run 4-6 months a year minor repairs,overhaul time.Minor repairs to remove the body dust,check the resistance of the coil insulation,wiring is firm,the timely removal of hidden dangers.Overhaul should dismantle the motor,used both inside and outside of blowing compressed air,check the bearing wear,replacement of the grease.

　　激振力的調整

　　振動電機每端出軸均有一個固定偏心塊和一個可調偏心塊，調節可調偏心塊和固定偏心塊之間的夾角可改變激振力的大小。出廠時可調偏心塊和固定偏心塊之間的夾角為0°，這時的激振力為振動電機的額定激振力F,不同夾角時的激振力如表2

　　Adjustment of excitation force

　　Each end of the shaft vibration motor has a fixed eccentric block and an adjustable eccentric block,adjustable between the eccentric block and a fixed eccentric block angle can change the size of the exciting force.The factory can be adjusted between the eccentric block and a fixed eccentric block angle of 0 degrees,the exciting force then rated the exciting force of the vibrating motor of F,the exciting force at different angles as shown in Table 2.

　　表2(Table two)

　　要特別注意，調整激振力時，要將振動電機兩端出軸上的可調偏心塊向同一個方向，兩端調相同的角度。

　　Special attention should be paid to the adjustment of exciting force,vibration motor,will from both ends of the adjustable eccentric block in the same direction on the shaft,both ends of the same angle adjustment.

　　訂貨須知

　　訂貨時應說明型號和臺數。

　　振動電機在停車時，偏心塊將因本身慣性而繼續轉動一段時間，要求振動電機迅速停車時，應采用反接制動。本公司配有專用控制箱，建議用戶訂貨時配套訂購，以保證振動電機停車平穩，防止停車過程中因通過共振區振幅加大而造成零部件損壞。

　　Ordering instruction

　　When ordering,should indicate the type and number.

　　The vibrating motor in the parking lot,the eccentric block will because of inertia and continue to rotate for a period of time,requirements of vibration motor quickly when parking,should use the reverse braking.The company is equipped with a special control box,advice when user ordering matching order,to ensure stable vibration motor parking,prevent the parking process because of through the resonance amplitude increase caused by the damage of the components.

　　TZDC系列技術數據

　　TZDC series technical data

　　帶A為調速電機Adjustable speed motor is with A.

　　TZD系列技術數據

　　TZD series technical data

　　帶A為調速電機

　　Adjustable speed motor is with A.